Page 1
A-607R
2
1. SAFETY INFORMATION
This service manual is intended for qualified service technicians; it is not meant for the casual
do-it-yourselfer. Qualified technicians have the necessary test equipment and tools, and have been
trained to properly and safely repair complex products such as those covered by this manual.
Improperly performed repairs can adversely affect the safety and reliability of the product and may
void the warranty. If you are not qualified to perform the repair of this product properly and safely, you
should not risk trying to do so and refer the repair to a qualified service technician.
WARNING
This product contains lead in solder and certain electrical parts contain chemicals which are known to the state of California to
cause cancer, birth defects or other reproductive harm.
Health & Safety Code Section 25249.6 Ð Proposition 65
NOTICE
(FOR CANADIAN MODEL ONLY)
Fuse symbols (fast operating fuse) and/or (slow operating fuse) on PCB indicate that replacement
parts must be of identical designation.
REMARQUE
(POUR MODéLE CANADIEN SEULEMENT)
Les symboles de fusible (fusible de type rapide) et/ou (fusible de type lent) sur CCI indiquent que
les pices de remplacement doivent avoir la mme dŽsignation.
ANY MEASUREMENTS NOT WITHIN THE
LIMITS OUTLINED ABOVE ARE INDICATIVE
OF A POTENTIAL SHOCK HAZARD AND
MUST BE CORRECTED BEFORE RETURN-
ING THE APPLIANCE TO THE CUSTOMER.
2. PRODUCT SAFETY NOTICE
Many electrical and mechanical parts in the appliance
have special safety related characteristics. These are
often not evident from visual inspection nor the
protection afforded by them necessarily can be obtained
by using replacement components rated for voltage,
wattage, etc. Replacement parts which have these
special safety characteristics are identified in this
Service Manual.
Electrical components having such features are
identified by marking with a
on the schematics and
on the parts list in this Service Manual.
The use of a substitute replacement component which
does not have the same safety characteristics as the
PIONEER recommended replacement one, shown in the
parts list in this Service Manual, may create shock, fire,
or other hazards.
Product Safety is continuously under review and new
instructions are issued from time to time. For the latest
information, always consult the current PIONEER
Service Manual. A subscription to, or additional copies
of, PIONEER Service Manual may be obtained at a
nominal charge from PIONEER.
(FOR USA MODEL ONLY)
1. SAFETY PRECAUTIONS
The following check should be performed for the
continued protection of the customer and service
technician.
LEAKAGE CURRENT CHECK
Measure leakage current to a known earth ground
(water pipe, conduit, etc.) by connecting a leakage
current tester such as Simpson Model 229-2 or
equivalent between the earth ground and all exposed
metal parts of the appliance (input/output terminals,
screwheads, metal overlays, control shaft, etc.). Plug
the AC line cord of the appliance directly into a 120V
AC 60 Hz outlet and turn the AC power switch on. Any
current measured must not exceed 0.5 mA.
Device
under
testLeakage
current
tester
Earth
ground Reading should
not be above
0.5 mA
Also test with
plug reversed
(Using AC adapter
plug as required)Test all
exposed metal
surfaces
AC Leakage Test
Page 2
3
A-607R
2.1 PACKING
Mark No. Description Part No.
2. EXPLODED VIEWS AND PARTS LIST
NOTES: · Parts marked by "NSP" are generally unavailable because they are not in our Master Spare Parts List.
· The mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
· Screws adjacent to mark on the product are used for disassembly.
1 Operating Instructions See Contrast table (2)
(English)
2 Operating Instructions See Contrast table (2)
(German)
3 Operating Instructions See Contrast table (2)
(French/Italian/Dutch/Swedish/Spanish/Portugese)
NSP 4 Warranty Card See Contrast table (2)
5 Remote Control Unit (CU-A018) AXD7187
6 Battery Cover AZN2249
NSP 7 Dry Cell Battery (R6P,AA) AEX-010
8 Side Protector L AHA7127
9 Side Protector R AHA7128
10 Sub Pad AHA7245
11 Packing Case See Contrast table (2)
NSP 12 Literature Bag AHG-117
13 Packing Sheet AHG1016
NSP 14 Air Cap See Contrast table (2)
15 Power Cord See Contrast table (2)
16 Power Cord with Fuse See Contrast table (2)
17 Fuse (T5A) See Contrast table (2)
18 Operating Instructions See Contrast table (2)
(Spanish/Chinese)
NSP 19 Caution Label 220V See Contrast table (2)
(1) PACKING PARTS LIST
(2) CONTRAST TABLE
A-607R/MV, MY/EW, MY/GR and SD types are constructed the same except for the following :
k r a M.o Nno i t p i r c s e D d n a l o b m y S. o N t r a P
s k r a m e R
e p y T V Mep y T W E / Y Mep y T R G / Y Mep y T D S
P S N
P S N1
2
3
4
1 1
4 1
5 1
6 1
7 1
8 1
9 1) h s i l g n E ( s n o i t c u r t s n I g n i t a r e p O
) n a m r e G ( s n o i t c u r t s n I g n i t a r e p O
s n o i t c u r t s n I g n i t a r e p O
) e s e u g u t r o P / h s i n a p S / h s i d e w S / h c t u D / n a i l a t I / h c n e r F (
d r a C y t n a r r a W
e s a C g n i k c a P
p a C r i A
d r o C r e w o P
e s u F h t i w d r o C r e w o P
) A 5 T ( e s u F
( s n o i t c u r t s n I g n i t a r e p Oes e n i h C / h s i n a p S)
V 0 2 2 l e b a L n o i t u a C1 6 1 7 B R A
d e s u t o N
d e s u t o N
2 2 0 7 Y R A
3 5 6 7 D H A
7 8 0 1 G H A
d e s u t o N
6 5 1 1 G D A
6 4 0 1 K E A
d e s u t o N
d e s u t o N1 6 1 7 B R A
1 1 2 7 C R A
2 1 2 7 C R A
2 2 0 7 Y R A
3 5 6 7 D H A
d e s u t o N
4 5 1 1 G D A
d e s u t o N
d e s u t o N
d e s u t o N
d e s u t o Nd e s u t o N
1 1 2 7 C R A
d e s u t o N
2 2 0 7 Y R A
3 5 6 7 D H A
d e s u t o N
4 5 1 1 G D A
d e s u t o N
d e s u t o N
d e s u t o N
d e s u t o Nd e s u t o N
d e s u t o N
d e s u t o N
d e s u t o N
5 7 6 7 D H A
d e s u t o N
8 5 1 1 G D A
d e s u t o N
d e s u t o N
0 1 2 7 C R A
3 0 0 7 R R A
6
12
14 17
16
13
Separate Separate
8
11
9
5
7 15
MV type Only
Except
MV type
1 (MV and MY/EW
types Only)
3 (MY/EW
type Only) 2 (MY/EW and
MY/GR types
Only)
10
19
(SD type
Only) 18 (SD
type Only)4 (MY/EW,
MY/GR and
MVtypes
Only)
FRONT
